investigation on concrete with stone crusher dust as fine aggregate
investigation on concrete with stone crusher dust as fine aggregate
Zhengzhou, Henan China
24 hours At your service

investigation on concrete with stone crusher dust as fine aggregate

  • Home
  • / Product
  • / investigation on concrete with stone crusher dust as fine aggregate

Investigations on concrete with stone crusher dust as fine ...

The investigations indicate that stone crusher dust has a good potential as fine aggregate in concrete construction. Crusher dust not only reduces the cost of construction but also helps reduce ...

More

Study On Concrete With Stone Crusher Dust As Fine

2014-2-28  Concrete designated as Mix A ( 1 : 1.40 : 3.5, w/c = 0.54) with river sand as fine aggregate, and Mix B ( 1 : 1.6 : 3.5; w/c = 0.53) with stone crusher dust were used in the investigations, Table3. the mix proportions were based on IS 10262 : 1982 and SP 23 : 1982 for M 20 grade concrete with a target strength of 24 MPa.

More

(PDF) Crushed stone waste as fine aggregate for concrete

The suitability of crushed stone dust waste as fine aggregate for concrete was accessed by comparing its basic properties with that of conventional concrete. Crushed stone

More

Investigation on Waste Plastic Fibre Reinforced Concrete ...

2020-9-21  investigations on concrete mixes with stone crusher dust as fine aggregate. They conclude stone crusher dust has a good alternative material for river sand [2]. R.Kandasamy reported that with addition of domestic plastic fibres in the concrete there is appreciable increase in compressive

More

Study On Concrete With stone Dust - Seminars Topics

2017-7-1  The investigation done by Student on the use of stone crusher dust in concrete as an alternative to fine aggregate are presented in this report. Standard

More

(PDF) Stone Dust in Concrete: Effect on Compressive

2021-11-15  In the present investigation, an experimental program was carried out to study the workability and compressive strength of concrete made using stone dust as

More

Utilization of Stone Dust as Fine Aggregate Replacement

2015-4-30  of fine aggregate with stone dust. The results shows strength of concrete increases within 5-12 percent up to 50 percent replacement of fine aggregate. And at 60 percent stone dust in concrete the maximum value of compressive strength is obtained which is 17 percent more than referral concrete (concrete with zero percent stone dust).

More

An Experimental study on Crushed Stone Dust as Fine ...

2018-1-1  The Narmada River sand is used as NS. (ii) Crushed Stone dust is a fine material formed during the process of conversion of rock into aggregate and has particle size ranging from 4 mm to dust size (> 0.075mm). It was procured from stone crusher plant producing 20 mm downgraded aggregate, M/s Maa Pitambara Stone situated at Neelbad, Bhopal (India).

More

BEHAVIOR OF CONCRETE ON REPLACEMENT OF SAND

2020-10-15  waste. The investigation on the use of Quarry Stone Dust in concrete as an alternative to sand as fine aggregate are presented in this report. report. Standard concrete cubes(150x150x150 mm), prisms (100x100x500 mm) were tested. The strength in direct compression at 7 days and 28

More

Use of crushed rock powder as replacement of fine ...

Being a worth less material, stone dust can be used in concrete as replacement material of fine aggregate with proper investigation. Nagabhusana and Bai (2011) reported that crushed stone powder ...

More

Study On Concrete With stone Dust - Seminars Topics

2017-7-1  The investigation done by Student on the use of stone crusher dust in concrete as an alternative to fine aggregate are presented in this report. Standard concrete cubes (150 mm), cylinders (150x300 mm), prisms (100x100x500 mm) as

More

Investigation on Waste Plastic Fibre Reinforced Concrete ...

2020-9-21  investigations on concrete mixes with stone crusher dust as fine aggregate. They conclude stone crusher dust has a good alternative material for river sand [2]. R.Kandasamy reported that with addition of domestic plastic fibres in the concrete there is appreciable increase in compressive

More

An Experimental study on Crushed Stone Dust as Fine ...

2018-1-1  The Narmada River sand is used as NS. (ii) Crushed Stone dust is a fine material formed during the process of conversion of rock into aggregate and has particle size ranging from 4 mm to dust size (> 0.075mm). It was procured from stone crusher plant producing 20 mm downgraded aggregate, M/s Maa Pitambara Stone situated at Neelbad, Bhopal (India).

More

AN EXPERIMENTAL INVESTIGATION ON THE STRENGTH

2017-11-15  20% replacement of cement with Stone Dust and 50% replacement of fine aggregate with Crushed fine aggregate. Key Words: Stone Dust, Crushed fine aggregate, quarry dust, Flexural Strength, concrete. 1.INTRODUCTION Cement is the most active component of concrete usually has the greatest unit cost, its selection and proper use are

More

Effective Utilization of Crusher Dust in Concrete Using ...

2021-6-4  Crusher dust is a byproduct generated from quarrying activities involved in the production of crushed coarse aggregate. The residue from stone crusher is further washed with water to remove the excess fines so that the fraction confirming to the IS 383 – 1970 specifications can be extracted. It is possible to use such manufactured sand as ...

More

Experimental Investigation on Quarry Dust as a Partial ...

2020-11-23  Investigation on Stone Dust As Partial Replacement Of Fine Aggregate In Concrete.” Journal Of Academia And Industrial Research (JAIR) Volume 3, Issue 5 October 2014. [10] Dr. Pofale A.D., Quadri Syed Raziuddin (2013). “Effective Utilization of Crusher Dust In Concrete Using Portland Pozzolana Cement”.

More

IJESRT

2018-10-11  In the present investigation, stone dust, a waste material obtain from crusher plant is used as partial replacement of fine aggregate. M25 grade of concrete was considered for this investigation with a final mix proportion of 1:1.65:3 at w/c ratio of 0.50. The replacement levels of natural fine aggregate with stone dust were 30-

More

EFFECT OF CONTENTS OF MICROFINES IN CRUSHED

2019-2-26  The locally obtained quarry dust was used as a partial replacement for fine aggregate in this investigation. The sample of quarry dust (Fig. 4) was analyzed and the results of sieve analysis are presented in Table 2. Figure 4 also presents graphical results of an XRD analysis of a sample of unwashed crushed sand obtained from Mumbai.

More

Use of Quarry Dust to Replace Sand in Concrete – An ...

2021-6-4  Index Terms- Concrete, quarry dust, river sand, compressive strength. I. INTRODUCTION oncrete is the most widely used composite material today. The constituents of concrete are coarse aggregate, fine aggregate, binding material and water. Rapid increase in construction activities leads to acute shortage of conventional

More

Investigation of the mechanical strength of stone dust and ...

2021-1-1  The stone dust passing through 4.75 mm sieve has been utilized as the replacement of natural sand. This dust was obtained from a local stone crusher plant. The stone dust in the present study. Similar to the sand, the silt has also been tested for various characteristics in the laboratory. Table 4 shows the results of the laboratory testing.

More

Study On Concrete With stone Dust - Seminars Topics

2017-7-1  The investigation done by Student on the use of stone crusher dust in concrete as an alternative to fine aggregate are presented in this report. Standard concrete cubes (150 mm), cylinders (150x300 mm), prisms (100x100x500 mm) as

More

An Experimental study on Crushed Stone Dust as Fine ...

2018-1-1  The Narmada River sand is used as NS. (ii) Crushed Stone dust is a fine material formed during the process of conversion of rock into aggregate and has particle size ranging from 4 mm to dust size (> 0.075mm). It was procured from stone crusher plant producing 20 mm downgraded aggregate, M/s Maa Pitambara Stone situated at Neelbad, Bhopal (India).

More

Experimental Investigation on Quarry Dust as a Partial ...

2020-11-23  Investigation on Stone Dust As Partial Replacement Of Fine Aggregate In Concrete.” Journal Of Academia And Industrial Research (JAIR) Volume 3, Issue 5 October 2014. [10] Dr. Pofale A.D., Quadri Syed Raziuddin (2013). “Effective Utilization of Crusher Dust In Concrete Using Portland Pozzolana Cement”.

More

EFFECT OF REPLACING SHARP SAND WITH STONE DUST

2021-4-19  Concrete is very variable material, having a wide range of strengths and stress-strain curve. Concrete composite material whose basic properties are related to the characteristic of constituent element, especially the aggregate. This research aimed to investigate the effect of replacing sharp sand with stone dust as an alternative to only river sand.

More

EFFECT OF CONTENTS OF MICROFINES IN CRUSHED

2019-2-26  The locally obtained quarry dust was used as a partial replacement for fine aggregate in this investigation. The sample of quarry dust (Fig. 4) was analyzed and the results of sieve analysis are presented in Table 2. Figure 4 also presents graphical results of an XRD analysis of a sample of unwashed crushed sand obtained from Mumbai.

More

Effect of demolished concrete and stone crusher dust on ...

2021-1-1  Stone crusher dust can replace up to 50% sand in production of paver blocks without decrease in physical mechanical strength . In this study, NCA was replaced by coarse RCA and river sand by SCD for manufacturing of M−40 grade concrete paver blocks and mechanical durability performance were evaluated.

More

Geo Polymer Concrete with the Replacement of Granite ...

2020-4-1  concrete with stone dust as fine aggregate, draws the following conclusions-The concrete cubes with crusher dust developed about 17% higher strength in compression, more split tensile strength and 20% more flexural strength (Modulus of Rupture) than the

More

An Investigation into the Use of Manufactured Sand as a ...

2016-6-2  2.2. Fine Aggregate Tests. As discussed earlier, the grading of the fine aggregate is an important factor that influences the performance of concrete, therefore all fine aggregates were tested for particle size distribution according to BS EN 933-1:1997.

More

Use of Quarry Dust to Replace Sand in Concrete – An ...

2021-6-4  Index Terms- Concrete, quarry dust, river sand, compressive strength. I. INTRODUCTION oncrete is the most widely used composite material today. The constituents of concrete are coarse aggregate, fine aggregate, binding material and water. Rapid increase in construction activities leads to acute shortage of conventional

More

pixie dust technology pdf - getdocumentationfo

2021-11-7  Stone crusher dust as a fine aggregate in Concrete for paving blocks ABSTRACT Concrete paving blocks are ideal materials on the footpaths for easy laying, better look and finish. In this paper, a parametric experimental study for producing paving blocks using crusher dust is presented. Some of the physical and mechanical properties of paving blocks

More